Application of pH control to a tubular flow reactor

?. Halil Vural; Ayla Altinten; Hale Hapo?lu; Sebahat Erdo?an; Mustafa Alpbaz

doi:10.1016/j.cjche.2014.10.002

Your Location：

Home >

Browse articles >

Application of pH control to a tubular flow reactor

过程系统工程与过程安全 | Updated：2026-01-06

- Application of pH control to a tubular flow reactor
- Application of pH control to a tubular flow reactor
- 中国化学工程学报（英文版） 2015年23卷第1期页码：145-161
- Affiliations：
  
  2 Gazi University, Faculty of Engineering, Department of Chemical Engineering, Maltepe,Ankara,Turkey,06570
- Author bio：
- Funds：
- DOI：10.1016/j.cjche.2014.10.002
  中图分类号：
- 纸质出版：2015
- Accepted：
Scan QR Code
?. Halil Vural, Ayla Altinten, Hale Hapo?lu, 等. Application of pH control to a tubular flow reactor[J]. 中国化学工程学报（英文版）, 2015,23(1):145-161.

İ. Halil Vural, Ayla Altinten, Hale Hapoğlu, Sebahat Erdoğan, Mustafa Alpbaz . Application of pH control to a tubular flow reactor[J]. Chin.J.Chem.Eng., 2015, 23(1): 145-161.
?. Halil Vural, Ayla Altinten, Hale Hapo?lu, 等. Application of pH control to a tubular flow reactor[J]. 中国化学工程学报（英文版）, 2015,23(1):145-161. DOI： 10.1016/j.cjche.2014.10.002.

İ. Halil Vural, Ayla Altinten, Hale Hapoğlu, Sebahat Erdoğan, Mustafa Alpbaz . Application of pH control to a tubular flow reactor[J]. Chin.J.Chem.Eng., 2015, 23(1): 145-161. DOI： 10.1016/j.cjche.2014.10.002.

摘要

Abstract

Tubular flow reactors are mainly used in chemical industry and waste water discharged units. Control of output variables is very difficult because of the existence of high dead-time in these types of reactors. In the present work

sodium hydroxide and acetic acid solutions were sent to the tubular flow reactor. The aim was to control pH at 7 in the nonlinear region. The pH control of a tubular flow reactor with high time delay and a highly nonlinear behavior in pH neutralization reaction was investigated experimentally in the face of the various load and set point changes. Firstly

efficiency of conventional Proportional-Integral-Derivative (PID) algorithm in the experiments was tested. Then self-tuning PID (STPID) control system was applied by using the ARMAX model. The model parameters were calculated from input-output data by using PRBS signal as disturbance and Bierman algorithm. Lastly

the experimental fuzzy control of pH based on fuzzy model was achieved to compare the success of fuzzy approach with the performance of other control cases studied.

关键词

Keywords

references

浏览量

155

Downloads

CSCD

文章被引用时，请邮件提醒。

Submit

工具集

关联资源

Dynamic temperature control of dividing wall batch distillation with middle vessel based on neural network soft-sensor and fuzzy control

Kinetic modeling of gamma-aminobutyric acid production by Lactobacillus brevis based on pH-dependent model and rolling correction

Pole-placement self-tuning control of nonlinear Hammerstein system and its application to pH process control

The Effect of pH Control on Acetone–Butanol–Ethanol Fermentation by Clostridium acetobutylicum ATCC 824 with Xylose and D-Glucose and D-Xylose Mixture

Robust Non-fragile PID Controller Design for the Stroke Regulation of Metering Pumps