Experimental and modeling study of micromixing characteristics in a stirred tank integrated with annular jet flow

Wu Guangshuo; Cai Ziqi; Li Zhipeng; Wang Junhao; Gao Zhengming

doi:null

Your Location：

Home >

Browse articles >

Experimental and modeling study of micromixing characteristics in a stirred tank integrated with annular jet flow

Updated：2026-05-14

- Experimental and modeling study of micromixing characteristics in a stirred tank integrated with annular jet flow
- Experimental and modeling study of micromixing characteristics in a stirred tank integrated with annular jet flow
- 中国化学工程学报（英文） 2026年90卷第2期页码：249-260
- Affiliations：
  
  State Key Laboratory of Chemical Resource Engineering, School of Chemical Engineering, Beijing University of Chemical Technology, Beijing 100029, China
- Author bio：
  
  Corresponding authors. E-mail addresses: wangjunhao@buct.edu.cn (J. Wang).
  Corresponding authors. E-mail addresses: gaozm@mail.buct.edu.cn (Z. Gao).
- Funds：
  
  the financial support from the China Petrochemical Corporation(222129;224285;224108)
- DOI：
  中图分类号：
- 收稿：2025-07-31，
  
  修回：2025-09-22，
  
  录用：2025-09-23，
  
  网络首发：2025-12-15，
  
  纸质出版：2026-02
- Accepted：
Scan QR Code
Wu Guangshuo, Cai Ziqi, Li Zhipeng, 等. Experimental and modeling study of micromixing characteristics in a stirred tank integrated with annular jet flow[J]. 中国化学工程学报（英文）, 2026,90(2):249-260.

Wu Guangshuo, Cai Ziqi, Li Zhipeng, et al. Experimental and modeling study of micromixing characteristics in a stirred tank integrated with annular jet flow[J]. Chinese Journal of Chemical Engineering, 2026, 90(2): 249-260.
Wu Guangshuo, Cai Ziqi, Li Zhipeng, 等. Experimental and modeling study of micromixing characteristics in a stirred tank integrated with annular jet flow[J]. 中国化学工程学报（英文）, 2026,90(2):249-260. DOI：

Wu Guangshuo, Cai Ziqi, Li Zhipeng, et al. Experimental and modeling study of micromixing characteristics in a stirred tank integrated with annular jet flow[J]. Chinese Journal of Chemical Engineering, 2026, 90(2): 249-260. DOI：

摘要

Abstract

To enhance the micromixing in chemical processes

a jet-stirred tank reactor (JSTR) was developed by integrating an annular jet with the width of 0.38 mm and 0.60 mm into a 81 L stirred tank to provide localized energy intensification. The iodide—iodate reaction method was used to evaluate the micromixing performance under different operating and structural conditions. Results showed that the micromixing time determined by the incorporation model decreased with increasing impeller speed and jet width

while the feeding position and jet velocity can significantly influence the micromixing due to jet deflection. The micromixing time in the JSTR ranged from 10 to 30 ms

representing a reduction of up to 3.45 times compared with the situation that only stirred tank was used. Numerical simulations of flow in the JSTR revealed four typical flow patterns illustrating the way by which the jet can affect the micromixing within the reactor. Furthermore

an operating diagram for mapping the micromixing time based on energy dissipation rate analysis was developed.

关键词

Keywords

references

A. Nie, Z.M. Gao, L. Xue, Z.Q. Cai, G.M. Evans, A. Eaglesham, Micromixing performance and the modeling of a confined impinging jet reactor/high speed disperser, Chem. Eng. Sci.184(2018)14—24.

J. Bałdyga, R. Pohorecki, Turbulent micromixing in chemical reactors — a review, Chem. Eng. J. Biochem. Eng. J. 58(2)(1995)183—195.

Y. Song, M. Shang, G. Li, Z.H. Luo, Y. Su, Influence of mixing performance on polymerization of acrylamide in capillary microreactors, AIChE J 64(5)(2017) 1828—1840.

H.K. Chan, P.C. Kwok, Production methods for nanodrug particles using the bottom-up approach, Adv. Drug Deliv. Rev.63(6)(2011)406—416.

P. Guichardon, C. Baqueiro, N. Ibaseta, Villermaux—Dushman test of micromixing characterization revisited: kinetic effects of acid choice and ionic strength, Ind. Eng. Chem. Res. 60 (50) (2021) 18268—18282.

M.C. Fournier, L. Falk, J. Villermaux, A new parallel competing reaction system for assessing micromixing efficiency—experimental approach, Chem. Eng. Sci. 51 (22) (1996) 5053—5064.

R. King, Fluid Mechanics of Mixing: Modelling, Operations and Experimental Techniques. Springer, Netherlands, (1992).

J.R. Bourne, F. Kozicki, P. Rys, Mixing and fast chemical reaction—I: test reactions to determine segregation, Chem. Eng. Sci. 36 (10) (1981) 1643—1648.

D. Wang, Y. Qiu, Z. Chen, C. Gu, X. Ling, H. Peng, X. Yang, F. Yuan, J. Du, W. Yu, Characterization of micromixing intensification of impinging jet flow on a spinning disk reactor with a structured surface, Ind. Eng. Chem. Res. 63 (24) (2024)10782—10794.

Y. Ouyang, M.N. Manzano, K. Beirn aert, G.J. Heynderickx, K.M. van Geem, Micromixing in a gas—liquid vortex reactor, AIChE J. 67 (7)(2021)e17264.

F. Visscher, J. van der Schaaf, T.A. Nijhuis, J.C. Schouten, Rotating reactors—a review, Chem. Eng. Res. Des. 91 (10)(2013)1923—1940.

M. Assirelli, E.J.W. Wynn, W. Bujalski, A. Eaglesham, A.W. Nienow, An extension to the incorporation model of micromixing and its use in estimating local specific energy dissipation rates, Ind. Eng. Chem. Res. 47 (10) (2007) 3460—3469.

W. Li, X. Geng, Y. Bao, Z. Gao, Micromixing characteristics in the impeller discharging area in aerated stirred tank, J. Chem. Eng. Jpn. 46 (11) (2013) 717—725.

J. Yang, Q. Zhang, Z.-S. Mao, C. Yang, Enhanced micromixing of Non-Newtonian fluids by a novel zigzag punched impeller, Ind. Eng. Chem. Res. 58(16)(2019)6822—6829.

B. Liu, N. Sun, Z. Jin, Y. Zhang, B. Sunden, Numerical investigation and estimating correlation of micromixing performance of coaxial mixers, Ind. Eng. Chem. Res. 58 (49) (2019) 22376—22388.

E. Schaer, P. Guichardon, L. Falk, E. Plasari, Determination of local energy dissipation rates in impinging jets by a chemical reaction method, Chem. Eng. J. 72(2)(1999)125—138.

Y. Wu, Y. Xiao, Y. Zhou, Micromixing in the submerged circulative impinging stream reactor, Chin. J. Chem. Eng. 11 (4)(2003)54—59.

H. Monnier, A.M. Wilhelm, H. Delmas, The influence of ultrasound on micromixing in a semi-batch reactor, Chem. Eng. Sci. 54 (13-14) (1999) 2953—2961.

J. Jordens, B. Bamps, B. Gielen, L. Braeken, T. van Gerven, The effects of ultrasound on micromixing, Ultrason. Sonochem. 32 (2016) 68—78.

S.D. Qin, J.F. Zhang, J. Zhang, D.B. Zhao, X. Xu, D.C. Jiang, Study on mixing performance of high-viscosity fluid in continuous microfluidic multistage stirrer, Ind. Eng. Chem. Res. 64(12)(2025)6407—6419.

L.h. Nouri, J. Legrand, N. Benmalek, F. Imerzoukene, A.-R. Yeddou, F. Halet, Characterisation and comparison of the micromixing efficiency in torus and batch stirred reactors, Chem. Eng. J. 142(1) (2008)78—86.

Z. Gao, J. Han, Y. Xu, Y. Bao, Z. Li, Particle image velocimetry (PIV) investigation of flow characteristics in confined impinging jet reactors, Ind. Eng. Chem. Res. 52 (33) (2013) 11779—11786.

P. Guichardon, L. Falk, J. Villermaux, Characterisation of micromixing efficiency by the iodide—iodate reaction system. Part II: kinetic study, Chem. Eng. Sci. 55 (19) (2000) 4245—4253.

P. Guichardon, L. Falk, Characterisation of micromixing efficiency by the iodide—iodate reaction system. Part I: experimental procedure, Chem. Eng. Sci. 55(19)(2000) 4233—4243.

Z. Li, Y. Xiao, W. Huai, L. Ding, Velocity characteristics of a round offset jet with different offset ratios in a counterflow, Flow Turbul. Combust. 107 (1) (2020)81—104.

J. Villermaux, R. David, Recent advances in the understanding of micromixing phenomena in stirred reactors, Chem. Eng. Commun. 21 (1-3) (1983) 105—122.

M.C. Fournier, L. Falk, J. Villermaux, A new parallel competing reaction system for assessing micromixing efficiency—determination of micromixing time by a simple mixing model, Chem. Eng. Sci. 51 (23) (1996) 5187—5192.

J. Baldyga, J.R. Bourne, Simplification of micromixing calculations. II. New applications, Chem. Eng. J. 42(2)(1989) 93—101.

J. Baldyga, J.R. Bourne, Simplification of micromixing calculations. I. Derivation and application of new model, Chem. Eng. J. 42 (2) (1989) 83—92.

E. Arian, W. Pauer, Contributions to the kinetics of the iodide-iodate test reaction for micromixing time calculation with extended incorporation models, Chem. Eng. Sci. 237(2021)116549.

H. Ye, J. Guo, X. Li, R. Chi, B. Long, Y. Han, W. Li, J. Wu, J. Zhang, Improving the accuracy of micromixing time using Villermaux—Dushman reaction with incorporation model, Chem. Eng. Sci. 306(2025)121254.

R.A. Antonia, B.R. Satyaprakash, A.K.M.F. Hussain, Measurements of dissipation rate and some other characteristics of turbulent plane and circular jets, Phys. Fluids 23 (4) (1980) 695—700.

K. Mahesh, The interaction of jets with crossflow, Annu. Rev. Fluid Mech. 45 (1)(2013)379—407.

浏览量

Downloads

CSCD

文章被引用时，请邮件提醒。

Submit

工具集

关联资源

Experimental and numerical investigations on micromixing performance of multi-orifice cross-flow jet mixers

Multiscale synergistic enhancement mechanism of solid—liquid mixing in multi-shaft stirred reactors under variable-speed operation

CFD investigation in the temperature effect on coal catalytic hydrogasification in the pressurized bubbling fluidized bed

Eulerian-Lagrangian simulation of dispersed liquid flow in turbulent stirred tanks

Consequence prediction using variable-length concentration time series for gas turbine enclosure