Benchmarking MDEA/PZ for CO<sub>2</sub> absorption from high CO<sub>2</sub>-content sources: Pilot study and comparison to Aspen Plus simulations

Can Demir; Isaac A. Løge; Jens K. Jørsboe; Hooman Fatoorehchi; Randi Neerup; Rasmus J. Friis; Jens Abildskov; Philip L. Fosbøl

doi:null

Your Location：

Home >

Browse articles >

Benchmarking MDEA/PZ for CO₂ absorption from high CO₂-content sources: Pilot study and comparison to Aspen Plus simulations

Updated：2026-08-24

- Benchmarking MDEA/PZ for CO₂ absorption from high CO₂-content sources: Pilot study and comparison to Aspen Plus simulations
- Benchmarking MDEA/PZ for CO₂ absorption from high CO₂-content sources: Pilot study and comparison to Aspen Plus simulations
- 中国化学工程学报（英文） 2026年94卷第6期页码：315-330
- Affiliations：
  
  Center for Energy Resources Engineering, Department of Chemical and Biochemical Engineering, Technical University of Denmark, Søltofts Plads 228A, Kongens Lyngby 2800, Denmark
  Rambøll Danmark, Hannemanns Allé 53, København S 2300, Denmark
  Process and System Engineering Center, Department of Chemical and Biochemical Engineering, Technical University of Denmark, Søltofts Plads 228A, Kongens Lyngby 2800, Denmark
- Author bio：
  
  Corresponding author. E-mail address: cande@kt.dtu.dk(C. Demir)
- Funds：
- DOI：
  中图分类号：
- 收稿：2025-08-12，
  
  修回：2025-12-09，
  
  录用：2025-12-10，
  
  网络首发：2026-02-10，
  
  纸质出版：2026-06
- Accepted：
Scan QR Code
Can Demir, Isaac A. Løge, Jens K. Jørsboe, 等. Benchmarking MDEA/PZ for CO₂ absorption from high CO₂-content sources: Pilot study and comparison to Aspen Plus simulations[J]. 中国化学工程学报（英文）, 2026,94(6):315-330.

Can Demir, Isaac A. Løge, Jens K. Jørsboe, et al. Benchmarking MDEA/PZ for CO₂ absorption from high CO₂-content sources: Pilot study and comparison to Aspen Plus simulations[J]. Chinese Journal of Chemical Engineering, 2026, 94(6): 315-330.
Can Demir, Isaac A. Løge, Jens K. Jørsboe, 等. Benchmarking MDEA/PZ for CO₂ absorption from high CO₂-content sources: Pilot study and comparison to Aspen Plus simulations[J]. 中国化学工程学报（英文）, 2026,94(6):315-330. DOI：

Can Demir, Isaac A. Løge, Jens K. Jørsboe, et al. Benchmarking MDEA/PZ for CO₂ absorption from high CO₂-content sources: Pilot study and comparison to Aspen Plus simulations[J]. Chinese Journal of Chemical Engineering, 2026, 94(6): 315-330. DOI：

摘要

Abstract

Absorption-based carbon dioxide (CO

) capture is limited by high regeneration energy and low cyclic capacity. Blends of methyldiethanolamine (MDEA) and piperazine (PZ) are promising for high CO

-content sources like biogas

outperforming conventional amines in both respects. However

their largescale CO

capture performance remains unexplored due to difficulties in obtaining reliable pilot-scale data. Here

we present

for the first time

pilot-scale data on MDEA/PZ blends through absorber experiments

validated

via

steady-state data reconciliation and compared with Aspen Plus simulations. MDEA/PZ blends were benchmarked under emulated biogas upgrading conditions in a 10 m high pilot absorber

processing feed gas with 38%-51% (vol) CO

. Lean-to-gas flow

solvent temperature

and PZto-MDEA ratio were varied in the pilot campaigns. Data reconciliation validated the steady states within a 95% confidence interval

enhancing dataset reliability and model accuracy. Solvent requirements are reduced by 45% using the lean temperatures of 30℃ compared to 50℃. Doubling the PZ concentration further reduced the solvent requirement by 25%.

关键词

Keywords

references

P.G. Kougias, I. Angelidaki, Biogas and its opportunities: a review, Front. Environ. Sci. Eng. 12 (3) (2018) 14.

K.C. Surendra, D. Takara, A.G. Hashimoto, S.K. Khanal, Biogas as a sustainable energy source for developing countries: opportunities and challenges, Renew. Sustain. Energy Rev. 31 (2014) 846-859.

A.A. Werkneh, Biogas impurities: environmental and health implications, removal technologies and future perspectives, Heliyon 8 (10) (2022) e10929.

T. Antukh, I. Lee, S. Joo, H. Kim, Hydrogenotrophs-based biological biogas upgrading technologies, Front. Bioeng. Biotechnol. 10 (2022) 833482.

L. Maggioni, C. Pieroni, Deliverable D5.2: Report on the Biomethane Injection into National Gas Grid, 2016.

R. Kapoor, P. Ghosh, M. Kumar, V.K. Vijay, Evaluation of biogas upgrading technologies and future perspectives: a review, Environ. Sci. Pollut. Res. Int. 26 (12) (2019) 11631-11661.

I. Angelidaki, L. Treu, P. Tsapekos, G. Luo, S. Campanaro, H. Wenzel, P.G. Kougias, Biogas upgrading and utilization: current status and perspectives, Biotechnol. Adv. 36 (2) (2018) 452-466.

F.R.H. Abdeen, M. Mel, M.S. Jami, S.I. Ihsan, A.F. Ismail, A review of chemical absorption of carbon dioxide for biogas upgrading, Chin. J. Chem. Eng. 24 (6) (2016) 693-702.

S. Sahota, G. Shah, P. Ghosh, R. Kapoor, S. Sengupta, P. Singh, V. Vijay, A. Sahay, V.K. Vijay, I.S. Thakur, Review of trends in biogas upgradation technologies and future perspectives, Bioresour. Technol. Rep. 1 (2018) 79-88.

T.N. Borhani, M.H. Wang, Role of solvents in CO 2 capture processes: the review of selection and design methods, Renew. Sustain. Energy Rev. 114 (2019) 109299.

X.M. Wu, Y.S. Yu, Z. Qin, Z.X. Zhang, The advances of post-combustion CO 2 capture with chemical solvents: review and guidelines, Energy Proc. 63 (2014) 1339-1346.

G. Rochelle, E. Chen, S. Freeman, D. van Wagener, Q. Xu, A. Voice, Aqueous piperazine as the new standard for CO 2 capture technology, Chem. Eng. J. 171 (3) (2011) 725-733.

A. Carranza-Abaid, R.R. Wanderley, H.K. Knuutila, J.P. Jakobsen, Analysis and selection of optimal solvent-based technologies for biogas upgrading, Fuel 303 (2021) 121327.

C. Chao, Y.M. Deng, R. Dewil, J. Baeyens, X.F. Fan, Post-combustion carbon capture, Renew. Sustain. Energy Rev. 138 (2021) 110490.

A. Gaur, J.W. Park, S. Maken, H.J. Song, J.J. Park, Landfill gas (LFG) processing via adsorption and alkanolamine absorption, Fuel Process. Technol. 91 (6) (2010) 635-640.

J.K. Jørsboe, S.H.B. Vinjarapu, R. Neerup, A.C. Møller, S. Jensen, J. Abildskov, P. Fosbøl, Mobile pilot plant for CO 2 capture in biogas upgrading using 30 wt% MEA, Fuel 350 (2023) 128702.

M. Sánchez Bas, A.J. Aragón, J.C. Torres, F. Osorio, Purification and upgrading biogas from anaerobic digestion using chemical absorption of CO 2 with amines in order to produce biomethane as biofuel for vehicles: a pilot-scale study, Energy Sources Part A Recovery Util. Environ. Eff. 44 (4) (2022) 10201-10213.

A. Mindaryani, W. Budhijanto, S.S. Ningrum, Continuous absorption of CO 2 in packed column using MDEA solution for biomethane preparation, IOP Conf. Ser. Mater. Sci. Eng. 162 (1) (2016) 012006.

V. Rajiman, H.N.A. Halim, A.M. Shariff, U.F.M. Ali, M.I.H.M. Dzahir, Potential of 2-amino-2-methyl-1-propanol solution as absorbent for CO 2 absorption from biogas, IOP Conf. Ser. Earth Environ. Sci. 765 (1) (2021) 012054.

F. Capra, F. Fettarappa, F. Magli, M. Gatti, E. Martelli, Biogas upgrading by amine scrubbing: solvent comparison between MDEA and MDEA/MEA blend, Energy Proc. 148 (2018) 970-977.

Y.C. Park, J.S. L ee, J.H. Moon, B.M. Min, D.M. Shim, H.J. Sung, Performance comparison of aqueous MEA and AMP solutions for biogas upgrading, Kor. J. Chem. Eng. 34 (3) (2017) 921-927.

S. Bishnoi, G.T. Rochelle, Absorption of carbon dioxide into aqueous piperazine: reaction kinetics, mass transfer and solubility, Chem. Eng. Sci. 55 (22) (2000) 5531-5543.

J.R. Ying, S. Raets, D. Eimer, The activator mechanism of piperazine in aqueous methyldiethanolamine solutions, Energy Proc. 114 (2017) 2078-2087.

H. Svensson, C. Hulteberg, H.T. Karlsson, Heat of absorption of CO 2 in aqueous solutions of N -methyldiethanolamine and piperazine, Int. J. Greenh. Gas Control 17 (2013) 89-98.

S. Bishnoi, G.T. Rochelle, Thermodynamics of piperazine/methyldiethanolamine/water/carbon dioxide, Ind. Eng. Chem. Res. 41 (3) (2002) 604-612.

A.H. Behroozi, N. Akbarzad, A. Ghaemi, CO 2 reactive absorption into an aqueous blended MDEA and TMS solution: experimental and modeling, Int. J. Environ. Res. 14 (3) (2020) 347-363.

A.H. Behroozi, M. Saeidi, A. Ghaemi, A. Hemmati, N. Akbarzad, Electrolyte solution ofMDEA-PZ-TMSfor CO 2 absorption; response surface methodology and equilibrium modeling, Environ. Technol. Innov. 23 (2021) 101619.

Rate-Based Model of the CO 2 Capture Process by Mixed PZ and MDEA Using Aspen plus,2014.

R. Neerup, K.L. Øbro, I.A. Løge, N. Kottaki, C.F. Frøstrup, I. Gyorbiro, M. Dimitriadi, H. Halilov, S. Jensen, J.L. Karlsson, P.L. Fosbøl, CO 2 capture pilot campaign: understanding solvent degradation of CESAR1 in cement plant operations, Chem. Eng. J. 510 (2025) 161542.

I.A. Løge, C. Demir, S.H.B. Vinjarapu, R. Neerup, E.H. Jensen, J.K. Jørsboe, M. Dimitriadi, V. Buvik, H. Halilov, C.F. Frøstrup, I. Gyorbiro, N. Kottaki, A.N. Jayan, S. Jensen, J.L. Karlsson, P.L. Fosbøl, Pilot-scale CO 2 capture in a cement plant with CESAR1: higher stripper pressure reduces energy demand and compression work but increases solvent degradation, Chem. Eng. J. 518 (2025) 163900.

P.L. Fosbøl, J. Gaspar, S. Ehlers, A. Kather, P. Briot, M. Nienoord, P. Khakharia, Y. Le Moullec, O.T. Berglihn, H. Kvamsdal, Benchmarking and comparing first and second generation post combustion CO 2 capture technologies, Energy Proc. 63 (2014) 27-44.

A. Gladis, N.F. Lomholdt, P.L. Fosbøl, J.M. Woodley, N. von Solms, Pilot scale absorption experiments with carbonic anhydrase-enhanced MDEA-Benchmarking with 30 wt% MEA, Int. J. Greenh. Gas Control 82 (2019) 69-85.

T.L. Sønderby, K.B. Carlsen, P.L. Fosbøl, L.G. Kiørboe, N. von Solms, A new pilot absorber for CO 2 capture from flue gases: measuring and modelling cap ture with MEA solution, Int. J. Greenh. Gas Control 12 (2013) 181-192.

E. Madsen, R. Neerup, A. Gladis, J.K. Jørsboe, N. von Solms, P.L. Fosbøl, Pressure drop of structured packing in pilot column and comparison to common correlations, Chin. J. Chem. Eng. 64 (2023) 281-291.

S.H.B. Vinjarapu, I.A. Løge, R. Neerup, A.H. Larsen, V.E. Rasmussen, J.K. Jørsboe, S.N.B. Villadsen, S. Jensen, J.L. Karlsson, J. Kappel, H. Lassen, P.Blinksbjerg, N. von Solms, P.L. Fosbøl, Learnings from up-scaling CO 2 capture:challenges and experiences with pilot work, Chem. Eng. Sci. 300 (2024) 120576.

S. Moioli, L.A. Pellegrini, Describing physical properties of CO 2 unloaded and loaded MDEA+PZ solutions, Chem. Eng. Res. Des. 138 (2018) 116-124.

A.H. Jalili, A.T. Zoghi, M. Shokouhi, A. Mehdizadeh, Vapor-liquid equilibria and density of CO 2 -loaded aqueous methyldiethanolamine + piperazine + sulfolane solutions, J. Chem. Eng. Data 69 (5) (2024) 1842-1861.

J.K. Jørsboe, E.H. Jensen, S. Jensen, P. Wiers, J. Karlsson, I.A. Løge, J. Abildskov, P. Fosbøl, Biogas upgrading with PZ/MDEA: pilot demonstration of absorber intercooling, cold solvent split and lean vapor compression, Fuel 396 (2025) 135296.

S. Bishnoi, G.T. Rochelle, Absorption of carbon dioxide i n aqueous piperazine/methyldiethanolamine, AIChE J. 48 (12) (2002) 2788-2799.

C.C. Chen, H.I. Britt, J.F. Boston, L.B. Evans, Local composition model for excess Gibbs energy of electrolyte systems. Part I: Single solvent, single completely dissociated electrolyte systems, AIChE J. 28 (4) (1982) 588-596.

D. Speyer, V. Ermatchkov, G. Maurer, Solubility of carbon dioxide in aqueous solutions of N -methyldiethanolamine and piperazine in the low gas loading region, J. Chem. Eng. Data 55 (1) (2010) 283-290.

V. Ermatchkov, Á. Pérez-Salado Kamps, G. Maurer, Solubility of carbon dioxide in aqueous solutions of N -methyldiethanolamine in the low gas loading region, Ind. Eng. Chem. Res. 45 (17) (2006) 6081-6091.

D.R. Kuehn, H. Davidson, Computer control. II. Mathematics of control, Chem. Eng. Prog. 57 (6) (1961) 44-47.

D.L. Ripps, Adjustment of experimental data, Chem. Eng. Prog. Symp. 61 (55) (1965) 8-13.

浏览量

Downloads

CSCD

文章被引用时，请邮件提醒。

Submit

工具集

关联资源

Engineering metal-organic framework architectures for enhanced carbon dioxide capture

CO2 capture by ternary ionic liquid non-aqueous phase change solvents

The carbon capture performance of phase change absorbent based on nanoparticle enhancement

Safety evaluation of rectisol process based on quantitative hazard and operability analysis

Dual-functional Li4SiO4derived from waste clay bricks for highly stable CO2capture and efficient thermal energy storage

Benchmarking MDEA/PZ for CO2 absorption from high CO2-content sources: Pilot study and comparison to Aspen Plus simulations

Benchmarking MDEA/PZ for CO2 absorption from high CO2-content sources: Pilot study and comparison to Aspen Plus simulations

DOI：

摘要

Abstract

关键词

Keywords

references

Benchmarking MDEA/PZ for CO₂ absorption from high CO₂-content sources: Pilot study and comparison to Aspen Plus simulations

Benchmarking MDEA/PZ for CO₂ absorption from high CO₂-content sources: Pilot study and comparison to Aspen Plus simulations